94 S10 Blazer front diff issues

Printable Version

Blazer Forums >> Mechanical & Maintenance >> Steering, Suspension & Drivetrain >> 94 S10 Blazer front diff issues

Page: [1]

Login Message << Older Topic   Newer Topic >>

94 S10 Blazer front diff issues - 9/2/2008 4:37:21 AM    WFD28   Posts: 9 Joined: 9/2/2008 Status: offline i have a 1994 S10 Blazer 4x4 w/ 4.3 Vortec, 4 door. I have had this truck for a while and have never had the 4wd working. When i put it into 4wd the transfer case locks in and the rear also locks with 4Lo. After any attempt to put it into 4wd it makes some odd noises, while driving down the road out of 4wd after such an atempt, the truck will start making a load howl, then a grinding noise as you slow, then at about 2 miles per hour, it makes a loud bang and it all stops. It does this for days and even once up to a month till i changed the cableand relieved pressure. Me and a friend put it on a lift and put it into 4wd and the front drive shaft rotates but meets no resistance. I have replaced the vaccum lines, the diaphram and the cable line to the front diff. My buddy suggested that i just go get a front end from the junk yard and do a swap. But i want to try and thing that can keep it cheaper. It was also mentioned to me that there is a fork inside the front diff that pulls the gears into 4wd. Is this true?and if so is that a buyable and driveway changable part. Any help is much appreciated. Post #: 1

RE: 94 S10 Blazer front diff issues - 9/2/2008 4:44:15 AM    swartlkk Posts: 14314 Joined: 5/1/2005 From: Waterloo, NY Status: online It definitely sounds like things are not working properly in the front axle engagement mechanism.  There is a fork that connects the passenger axle with the differential. You can buy a kit that replaces the problematic vacuum actuator with a cable for quick, positive engagement of the front axle, but that would only work if everything inside the front axle is working properly.  You can start by pulling on the cable yourself at the vacuum actuator, attempting to lock the front axle in. _____________________________ Kyle- 2004 Rainier 1970 Chevelle - Resto 1974 K5 Blazer - Resto (in reply to WFD28) Post #: 2

RE: 94 S10 Blazer front diff issues - 9/2/2008 4:51:38 AM    WFD28   Posts: 9 Joined: 9/2/2008 Status: offline ok....im gonna try to work on it today and see if i can get anything out of it. Its just driving me crazy and i need my 4wd for this winter. I will repost if i get anything new. Thanks (in reply to swartlkk) Post #: 3

RE: 94 S10 Blazer front diff issues - 9/2/2008 4:53:18 AM    swartlkk Posts: 14314 Joined: 5/1/2005 From: Waterloo, NY Status: online You can start by removing the three bolts where the cable attaches to the front diff.  If you pull there, the front end should be engaged.  To check, hold one wheel while spinning the other and the front driveshaft should turn. _____________________________ Kyle- 2004 Rainier 1970 Chevelle - Resto 1974 K5 Blazer - Resto (in reply to WFD28) Post #: 4

RE: 94 S10 Blazer front diff issues - 9/2/2008 8:30:27 AM    WFD28   Posts: 9 Joined: 9/2/2008 Status: offline i did what you said about taking the cable cover off the side of the diff on the front off my blazer and pulling it and trying to turn the drive shaft and it didn''''t turn. then i started my truck and put it in and out of 4wd and found what i think is a problem. my diaphram has constant vaccum so when it goes into 4wd it doesn''''t release the front diff when taken out of 4wd. Any suggestions? _____________________________ Jordan (in reply to swartlkk) Post #: 5

RE: 94 S10 Blazer front diff issues - 9/2/2008 8:33:20 AM    swartlkk Posts: 14314 Joined: 5/1/2005 From: Waterloo, NY Status: online If the actuator is getting constant vacuum, then the vacuum switch on the transfer case is most likely at fault.  But one thing is odd...  You say that when you pulled on the cable to engage the front axle, held one tire while spinning the other, the driveshaft did not move??  Can you clarify?  Was the transfer case in 4wd already?  Did the tire you were attempting to rotate move at all? < Message edited by swartlkk -- 9/2/2008 8:35:58 AM > _____________________________ Kyle- 2004 Rainier 1970 Chevelle - Resto 1974 K5 Blazer - Resto (in reply to WFD28) Post #: 6

RE: 94 S10 Blazer front diff issues - 9/2/2008 8:36:18 AM    WFD28   Posts: 9 Joined: 9/2/2008 Status: offline sorry....when i did it the drive shaft did spin is what i meant... but when i put the truck in 4wd the transfer case goes in fine....would that be if the unit on the case was bad?....also the vaccum line to the actuator come directly from the block...is that right? (in reply to swartlkk) Post #: 7

RE: 94 S10 Blazer front diff issues - 9/2/2008 8:38:45 AM    swartlkk Posts: 14314 Joined: 5/1/2005 From: Waterloo, NY Status: online If you were to follow the vacuum line from the actuator, it should go back to the transfer case.  There is a small vacuum switch on the top of the transfer case which directs engine vacuum to the actuator when the transfer case is in 4wd mode. _____________________________ Kyle- 2004 Rainier 1970 Chevelle - Resto 1974 K5 Blazer - Resto (in reply to WFD28) Post #: 8

RE: 94 S10 Blazer front diff issues - 9/2/2008 8:40:35 AM    WFD28   Posts: 9 Joined: 9/2/2008 Status: offline ok....im gonna go check that now...so ill post and let you know...thanks (in reply to swartlkk) Post #: 9

RE: 94 S10 Blazer front diff issues - 9/2/2008 10:48:29 AM    WFD28   Posts: 9 Joined: 9/2/2008 Status: offline good news my friend, good news....ran to advanced auto and bought one of those switchs and put it in and everything works good so far.....now just trying to find some place to go test it out and see how good it works.....Thanks again Kyle....you have been more help than anyone has helping me figure this out.....i will post again after i get back to tell if all is absolutely good.... _____________________________ Jordan (in reply to WFD28) Post #: 10

RE: 94 S10 Blazer front diff issues - 9/2/2008 11:30:35 AM    swartlkk Posts: 14314 Joined: 5/1/2005 From: Waterloo, NY Status: online Good deal, glad to help! _____________________________ Kyle- 2004 Rainier 1970 Chevelle - Resto 1974 K5 Blazer - Resto (in reply to WFD28) Post #: 11

Today's Posts
Most Active Topics
Make A Donation
Forum Rules & FAQ
RSS Feeds

Chevy Blazer Prices

Chevy Blazer
Trailblazer SS

Top 10 Posters
swartlkk 14314 drperry 3896 hanr3 3476 chevy lover 3411 m00nwater 3269 eurogoldls 3121 paddle_grl 2942 hillbillyino 2884 wolfpack 2788 xblazer01 2659

New Vendors
AMSOIL - Performance Oil Technology